battery tester HANDLING SAFETY
Batteries are utilized to power our automobiles, trucks, tractors, and construction or power equipment. You can get kinds of batteries such as lead-acid batteries, gel cells, and lead-calcium batteries. Most batteries contain sulfuric acid and lead. Because batteries contain chemicals, chemical reaction by-products, plus an electrical current they can pose a hazard to workers otherwise handled properly. Workers that operate, maintain, and recharge batteries should use caution.
Before working with a battery tester, you must have tactics pertaining to proper handling procedures.
* Consult vehicle and battery tester owners’ manuals for instructions on battery tester handling and hazard identification
* Wear personal protective equipment (PPE) for instance chemical splash goggles and then a face shield
* Wear acid-resistant equipment such as gauntlet style gloves, an apron, and boots
* Tend not to tuck pant legs into boots because spilled acid can pool towards the bottom within your boots and burn feet
Understand chemical hazards posed by batteries – sulfuric acid (electrolyte) in batteries is tremendously corrosive – Acid exposure may bring about skin irritation,
battery tester
, eye damage,
battery load tester
, respiratory irritation, and tooth enamel erosion
* Never lean on the battery tester while boosting, testing or charging it
* If acid splashes onto the skin or eyes, immediately flood the region with cool water not less than 15 minutes and seek medical assistance immediately
Always practice good hygiene and wash both your hands after getting through a battery tester and before eating. Any time you handle charge plates in a battery tester and you should not wash both your hands properly, you can be come across lead. Symptoms of lead exposure include swift changes in moods, loss in appetite, abdominal pain, difficulty sleeping, fatigue, headaches and decrease of motor coordination.
The chemical reaction by-products with a battery tester include oxygen and hydrogen gas. To as be explosive at high levels. Overcharging batteries may well create flammable gases. For that reason, comprehensively understand to store and look after batteries inside a well-ventilated office off all ignition sources and incompatible materials. Cigarettes, flames or sparks might lead to a battery bank tester to blow up. Do you are aware how to properly charge or ramp up a battery bank tester?
Before fixing an electric battery tester, disconnect the battery tester cables. To prevent yourself from sparking, always disconnect the negative battery tester cable first and reconnect it last. Be cautious with flammable fluids when working away at an assortment tester-powered engine. The electrical voltage developed by batteries can ignite flammable materials and cause severe burns. Workers happen to have been injured and killed when loose or sparking battery tester connections ignited gasoline and solvent fumes during vehicle maintenance.
battery tester maintenance tools could be covered with several layers of electrical tape to prevent yourself from sparking
* Place protective rubber boots on battery tester associations to stop sparking on impact where a tool does accidentally hit a terminal
* Clean it tester terminals using a plastic brush because wire brushes could create static and sparks
* Always remove your watches and jewellery before doing battery power tester. A short-circuit current can weld a ring or strap to metal and cause severe burns
Batteries is normally extremely dense and high
* Use proper lifting processes to avoid back injuries
* battery tester casings is often brittle and break easily; they should be handled carefully to stop an acid spill
* Make sure battery power tester is properly secured and upright within the vehicle or equipment
* In case your battery tester shows indications of scratches to the terminals, case or cover, change it out with one
Finally,
aptop battery tester
, make sure you get rid of old batteries properly.
* Speak to your battery tester supplier or local recycling center – NEVER throw a lead acid battery tester away while in the jobsite dumpster or trash roll-off
LAUSD New Construction – Weekly Construction Safety Bulletin
Topic: battery tester HANDLING SAFETY
TRAINING Check in SHEET
Date:
Time:
Volume of Associates Trained:
Number Minutes of your practice:
Presenter: (print & sign)
Other Topics Discussed:
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
19.
20.
21.
22.
23.
24.
25.
26.
27.
28.
29.
30.
31.
32.
33.
34.
35.
36.
37.
38.
39.
40.
41.
42.
43.
44.
45.
46.
47.
48.
49.
50.
51.
52.
53.
54.
55.
56.
57.
58.
59.
60.
61.
62.
63.
64.
65.
66.
67.
68.
69.
70.
71.
72.
Continue on backside if additional associates
LAUSD New Construction
Week of 30 April 2007
1
- aptop battery tester Battery Restoration Manual_2
- battery tester Service Manual Order Form – 13th Ed
- 12v battery tester Worksheets – Cognitive and Achi
4ba8ta7
iseaverfshj 